Bird nests in exhaust pipes
#11
Platinum Member
Platinum Member
For you garage tinkerers, here's an idea for a rainy day project:
I've made simple pipe plugs that work very well, refer to the sketch I made below.
Make some flat, round plates with center holes out of wood or plexiglass or whatever you may have laying around. In the middle, find some silicone closed cell sponge rubber or if nothing else is available cut a nice, thick slab out of a nerf football slightly smaller in diameter than the exhaust pipe. Mount a bolt or threaded rod with a nut on the inside which goes through all the parts. On the outside use a wingnut and a washer to cap it off.
Stick it in the exhaust pipe and tighten down the wingnut...When the sponge begins to compress, it will expand and fill the pipe.
You may also want to epoxy or 5200 the the bolt to the backside piece of wood so it doesn't turn on you when tightening the wingnut
Dangle a bright piece of ribbon from it as a reminder to "Remove Before Flight."
I've made simple pipe plugs that work very well, refer to the sketch I made below.
Make some flat, round plates with center holes out of wood or plexiglass or whatever you may have laying around. In the middle, find some silicone closed cell sponge rubber or if nothing else is available cut a nice, thick slab out of a nerf football slightly smaller in diameter than the exhaust pipe. Mount a bolt or threaded rod with a nut on the inside which goes through all the parts. On the outside use a wingnut and a washer to cap it off.
Stick it in the exhaust pipe and tighten down the wingnut...When the sponge begins to compress, it will expand and fill the pipe.
You may also want to epoxy or 5200 the the bolt to the backside piece of wood so it doesn't turn on you when tightening the wingnut
Dangle a bright piece of ribbon from it as a reminder to "Remove Before Flight."
#14
Platinum Member
Platinum Member
Originally posted by SteveS
Nurf Footballs! Just remember to take them out before starting. Forgot once and damn near knocked my buddies girlfriend on her ass.
Nurf Footballs! Just remember to take them out before starting. Forgot once and damn near knocked my buddies girlfriend on her ass.
Nice Redneck Kodack moment!
"Look Mahhh how far them smurf thangs go when yah fir'm up!"
Thread
Thread Starter
Forum
Replies
Last Post
lowblue320
General Boating Discussion
6
01-05-2008 07:16 PM