27' Fever 496 HO - Raylar
 

I have an '02 27'Fever with a 496 HO; I am seriously considering the Raylar engine upgrade, at present I have the Dana Marine Flowtorque exhaust installed. I would like any input on performance increases and possible cruising and top end performance increaces. Also any good or bad luck with the Raylar equipment. Thanks

Probably 8 or 9 mph boost with the HO525. I would expect the cruise speed to jump about 5 mph....

Ray @ Raylar builds a nice kit. They are reliable & low maint.. If you dont want to go boost then I would go that route.. If you dont mind boost then for your model year Procharger & whipple both make kits for it. Even though we prefer procharger on a lot of earlier stuff, I really like the whipple on the 496 engines..

BTW: we sell & install all 3 items I mentioned & they all will grab you some good power and give you more speed.. :)


Jamie / Lakeside Restorations

.

Raylar kit + Fountain 496 = a big kick for a decent buck!
 

Petesflht:

The Raylar BCK103 kit along with your Dana Marine exhaust will give you right at about 560HP at the crank which is about 10-15 more than a HP525 with about 25 ft/lbs more torque. You will need to re-prop most likely 2-3 inches in pitch but Fountains are fast boats and the added power should get you 8-10 mph once everything is dialed in and your cruise speed should improve very nicely. The Raylar equipped 496 is still naturally aspirated and the reliability you will have and the ability to still run 87 octane should make your future boating a lot of fun and still more economical at the gas pumps!
Let me know how we can help with your plans, the kits are in stock.

Best Regards,

Ray @ Raylar

I have the same set-up on a 04 model 27 Fever and would love to see how this goes before I do my upgrade. I dont know if you are running a 1.65 drive but that means you will have to turn a 30 plus prop after the upgrades unless you do a gear swap. I worry about docking with a 32 pitch. Whats top your top speed in stock form

I am running 1:5 gears with the stock Bravo 1 26" prop, am at 1100' above sea level, run about 68 at 5000 RPM's.

thats what I run.....68.6 gps in somewhat sticky water, two guys, 1/4 fuel

At least there consistant. Best of 68.5 GPS, 1.5, 26p. Over 400 hours, still runs the same. JC

So who is going to do the raylar?

My boat only runs 65-66ish best with 20 gallons 2 people then with 4 people it only runs 60ish. Is that the same with you guys? Do you lose that much speed with 2 more people? Have you pulled the turbulators out of the exhaust? Are you running labbed props?

I'm sure some one has a late model 27 that has done the Raylar We'll just have to wait for them to chime in